Alternator OEM Volvo or OEM Volkswagen

The V8s are good. I've had 2 pulleys/bearings go bad. The second failed completely, dropping the aux belt and damaging the timing cover. If you hear any weird noises from the engine bay, check your pulleys.

They're also not as bad on fuel as you'd expect. I've regularly seen 25mpg+ on a good run.

ABS modules and siren modules always fail, but are relatively cheap & easy to replace. Alternators also seem to be a weak point and are _really_ awkward to get to.

Maintenance I do oil every 10k km including all filters except fuel filter (every 2nd oil change). Basically never burns any oil, didn’t have to fill up at all. Only alternator broke down in extreme heat at 150k km but that’s expected.

I know my 2005 S60 alternator has a chip in it that is necessary to talk to the car's ECU so be careful buying aftermarket.

Assuming this is a T5 (5cyl) that price is about right for the dealer. I had my alternator replaced under warranty about 2 years ago and the billed price was right about 1350 for just the alt replacement.

Alternator stopped charging while driving and it slung grease all over the engine bay and hood.

oddly enough, I've only ever been completely stranded by failed alternators. once in my '98 Jetta GLX VR6 and once in my '09 Outback 3.0R

Replaced the alternator - twice. The second one failed as a result of a jump start scorching a relay in the voltage :-( Replaced the starter (in 2024), First alternator failed at 49K miles - oddly, when the car came out of the shop, the oil light came on and they found debris in the pick up so I got a new long block (under warranty so I suspect VOA knew of some defect for that model/year). Had one strut bearing fail at about 90K miles. I also had the AC recharged - car actually came from the factory with too much pressure (would ice up on humid days). I've stuck to dealer maintenance for everything except the strut repair and the usual annual CC alignments (well documented issue...) and keep all fluids (coolant/brakes/DSG) fresh. My car is still a daily driver - I'm probably due another battery soon but it runs great. I'm tempted to freshen the struts and control arms and add a rear sway bar - and possibly a tune, but I also see a Golf R in my future! I've run 3 other cars to 250K miles (Volvo 850, Highlander and an Audi 4KQ) and I don't see any reason why the dub can't get to 200K+ particularly if you keep up with a full maintenance plan. You may need to have some carbon blasting done at 100K, have the timing chain tension and service the PCV (leaving that too long leads to the carbon build up in the DI engines) but those are like 50K mile intervals

4 aftermarket alternators in a Volkswagen Vanagon… after the last shit the bed i insisted on a factory one. That solved the charging system issue.

When I finally bought another car and started preparing the Bora for sale, the alternator failed. The only real issue it ever gave me.

I just put a new alternator and the batty is dead again but when I jump it the car run fine until the next .morning I am going Crazy trying to figure this.