Windshield OEM Mazda or OEM Volvo

Make sure your windshield is Volvo original and not aftermarket.

I had my ND windshield replaced back in 2019 and they brought a genuine Mazda replacement. Not sure why, as the installer said it was unusual to use OEM. It is an involved process due to all the sensor reconfiguration required. I am not aware of an improved windshield replacement, but FWIW my replacement has been fine since 2019.

Best $250 I ever spent on my NA Miata bought in Nevada was a new windshield; makes the convertible experience so much better. Otherwise you can see perfectly in every direction except the one you’re headed toward! Highly recommend.

Best $250 I ever spent on my NA Miata bought in Reno was a new windshield; makes the convertible experience so much better. Highly recommend.

I will say my chilliest experience last January in the mountains of CO at night tested the defrosting ability of the windshield. I wish it had some extra heater wires because we had to rely on the heated air which made for a very toasty experience inside the car.

I have a similar crack, xc40 recharge. It’s got a bit bigger now and no unfortunately not covered by warranty unless one has purchased the windscreen warranty for $2000 on top of extended warranty and some other warranty, tires perhaps or wheels can’t remember but I declined.

my 24 v60 windshield cracked twice in a span of first 11 months and 11k mile of ownership. My previous car, I had one chip in 11 years and 132k miles. I wonder if Volvo windshield is weak or I have bad luck.

A pick-up truck with knobby tires kicked up a rock that chipped the windshield of my wife’s brand new Volvo within 30 minutes of her leaving the dealership.

One thing I am noticing though on a negative level is a very distinct and rather annoying whistling noise coming from the windshield (center area; rather top section at the level where the rear mirror is) starting at approximately 150kmh. I am driving often on the German Autobahn, the car is specified for high speed also - and I would simply not expect such a distinct whistling noise from a 80.000€ car.

People have experiences with a garbage windshield installation

https://www.reddit.com/r/CX5/comments/1nj1wb4/windshield_rattle_from_hell/